網站公告:

新聞中心

濟南精拓流體設備有限公司

電話:0531-69951198

郵箱:jingtuolt@163.com

傳真:0531-69951198

地址:濟南市歷城區西周南路9號

網址:http://www.madaboutmermaids.com

業內資訊

當前位置:首頁 - 新聞中心 - 業內資訊 - 增壓泵一直嗡嗡響是怎么回

增壓泵一直嗡嗡響是怎么回事?

發布時間:2022-09-17 16:09:40   發布人:http://www.madaboutmermaids.com
增壓泵一直嗡嗡響是怎么回事?其實這是很多廉價增壓泵的一個通病,造成這種現象的主要原因可能有以下幾點,氣液增壓泵廠家為您解說。
Why does the booster pump keep buzzing? In fact, this is a common problem of many cheap booster pumps. The main reasons for this phenomenon may be the following. The manufacturer of the gas-liquid booster pump will explain it to you.
1、壓力控制系統有問題。水泵一工作就達到了控制的壓力,水泵就不工作。是壓力控制系統有問題。水泵一停機,壓力又沒有了。
1. There is a problem with the pressure control system. As soon as the water pump reaches the control pressure, the water pump will not work. There is a problem with the pressure control system. As soon as the water pump stops, the pressure disappears again.
2、止回閥漏水。止回閥本身是只能進不能出的,如果用了質量不過關的止回閥,當泵腔內水壓增大時,已經被增壓的水就會回滲到泵的進水端造成泵腔內部壓力降低,傳感器檢測到水壓降低后就會重新啟動增壓泵進行補壓。
2. The check valve leaks. The check valve itself can only enter but not exit. If a check valve with poor quality is used, when the water pressure in the pump chamber increases, the pressurized water will seep back to the water inlet end of the pump, causing the pressure in the pump chamber to decrease. After the sensor detects that the water pressure decreases, it will restart the booster pump to supplement the pressure.
由于泵出水方向沒有任何用水,很快壓力重新補充上來,增壓泵馬上又休眠待機,往復循環就造成這種一響一停的現象。解決方法是重新更換質量過關的單向止回閥即可,其實絕大部分造成一響一停的原因就是止回閥造成的。
Since there is no water in the outlet direction of the pump, the pressure will be replenished soon, and the booster pump will sleep and stand by immediately. The reciprocating cycle will cause this phenomenon of "one ring and one stop". The solution is to replace the qualified one-way check valve. In fact, most of the reasons for "one click and one stop" are caused by the check valve.
3、泵出水管有地方漏水。出水管方向漏水導致一響一停也和止回閥漏水一響一停的原理是一樣的,都是因為泵腔內水壓降低導致水泵重新啟動補壓造成的,由于出水方向出水量很少,導致短時間壓力上升到設定壓力值而使增壓泵停機保壓。壓力達到后因為漏水又會造成水壓下降,增壓泵又重新補壓,往復循環就會造成一響一停的現象。
3. The outlet pipe of the pump leaks. The principle of "one click and one stop" caused by water leakage in the direction of the outlet pipe is the same as that of the check valve. Both are caused by the restart of the pump for pressure make-up due to the reduction of the water pressure in the pump chamber. Since there is little water output in the outlet direction, the pressure rises to the set value in a short time and the booster pump stops to maintain the pressure. After the pressure is reached, the water pressure will drop again due to water leakage, and the booster pump will supplement the pressure again. The reciprocating circulation will cause the phenomenon of one sound and one stop.
氣液增壓泵
4、傳感器故障。當壓力反饋不準確后,也會造成這種現象,原理其實都是一樣,當反饋了錯誤的低壓力之后增壓泵同樣會補壓,往復循環。
4. The sensor is faulty. When the pressure feedback is inaccurate, it will also cause this phenomenon. The principle is the same. When the wrong low pressure is fed back, the booster pump will also supplement the pressure and cycle back and forth.
5、用水頻次太大。如果增壓泵是壓差控制的,當頻繁有用水時,也會造成一啟一停的現象發生。其原因也是和出水管漏水是一樣的,而且這種情況可能一起一停會更頻繁,特別是沒有氣壓罐穩壓的尤為嚴重。
5. The frequency of water use is too high. If the booster pump is controlled by differential pressure, the phenomenon of one start and one stop will also occur when water is frequently used. The reason is the same as the water leakage of the outlet pipe, and this situation may be more frequent when the pipes are stopped together, especially when there is no pressure tank to stabilize the pressure.
如果要杜絕這種情況,建議將壓差式控制器改為變頻器控制,或者直接更換全新的變頻增壓泵可以解決用水時一響一停的現象。關注我們http://www.madaboutmermaids.com,了解更多!
If this situation is to be eliminated, it is recommended to change the differential pressure controller to frequency converter control, or directly replace a new variable frequency booster pump to solve the problem of "one sound and one stop" when using water. Follow us http://www.madaboutmermaids.com , learn more!
新聞推薦:
如何選擇放心的氣液增壓泵品牌 2022-10-17
氣液增壓泵的使用過程以及優勢 2022-10-10
廠家講解增壓泵產品的分類 2022-10-04
六個常見的氣液增壓泵故障及解決 2022-09-28
有關氣體增壓泵基礎知識的解答 2022-09-24
增壓泵一直嗡嗡響是怎么回事? 2022-09-17
增壓泵使用期間要了解到的故障原因 2022-09-13
氣液增壓泵的原理以及特點說明 2022-08-30
增壓泵處于好的工作狀態要了解其中參數 2022-08-24
有關設備增壓泵如何壓縮的呢 2022-08-17

13188935873

qq

欧洲精品无码一区二区三区在线播放,欧美性爱动图,欧美人与动交片免費播放,欧美成在线精品视频